Iranian Journal of Biosystem Engineering

Iranian Journal of Biosystem Engineering

Analyzing the MF285 tractor engine vibrations caused by different combinations of biodiesel, bioethanol and diesel as fuel by Response Surface Method

Document Type : Research Paper

Authors
Razi university of kermanshah
Abstract
In this study, the MF285 tractor engine vibrations resulting from the use of different combinations of biodiesel, bioethanol and diesel as fuel were studied. Engine vibrations in three directions and three engine speeds: 1000, 1600 rpm 2000 and ten fuel level was measured. To investigate the influence of measured parameters on engine vibration of factorial design in a randomized complete block design and response surface methodology were used. The results showed that vibration caused by the use of different combinations was less than of vibration caused by consumption of diesel fuel. The results showed that with increasing biodiesel fuel blends significantly reduce the vibration and the vibration increases with increasing engine speed. The vibration increased by increasing the bioethanol until 4% but then decreased. After optimization, the best fuel in terms of having the lowest vibration motor was B25E6D69.
Keywords
Subjects

Andrew, L. G., Dianne, C . H. & Brian j. s., (2007). The effect of piston friction on the torsional natural frequency of a reciprocating engine. Mechanical Systems and Signal Processing.  21(7), 2833-2837.
Ettefagh, M.M., Sadeghi, M.H, Pirouzpanah.V. & Arjmanditash H., (2008). Knock detection in spark ighition engines by vibration analysis of cylinder brock: A parametric modeling approach. journal of mechanical systems and signal processing. 22(6), 1495 -1514
Geng Z. & Chen J., (2005). Investigation into piston-slap induced vibration for engine condition simulation and monitoring , Journal of sound and vibration , 282, 735-751.
Hasan-Beigi, S.R., Johar, E., Ghobadian, B.,Abonajmi, M., Astan, V., (1391). Measurement and analysis of vibration signals 6-cylinder diesel engine with diesel and bio fuel mixtures in the time domain. In: Proceedings of 7th International Congress on Mechanization and Machinery in Agriculture, (In Farsi)
Hashemifard-Dehkordi, S.H., Almasi, M., Borgheai, A.M., Beheshti, B., (1393). The impact of bioethanol and diesel fuel blends on diesel engine vibration., Journal of Agricultural Machinery, 4(2), 243-236. (In Farsi)
Heidari, B., Hasan-Beigi, S.R., Ghobadian, B., (1391). Checking tiller engine vibration in the time domain using a mixture of diesel fuel and bio-diesel  In: Proceedings of 7th International Congress on Mechanization and Machinery in Agriculture, (In Farsi)
Hostens, I. & Ramon , H., (2003) descriptive analysis of combine cabin vibrations and their effects on the human body. Journal of sound and vibration. 266, 453-464
Keskin, A., (2010). The inflounce of ethanol-gasoline blends on spark ignition engine vibration characteristics and noise emissions. Energy sources , 32, 1851-1860.
Li, W., Ren, Y., Wang, X.B., Miao, H. & Huang, Z.H., (2007). Combustion characteristics of a
compression ignition engine fuelled with diesel–ethanol blends, Automobile Engineering, 222, 265-274.
Mc-cormick, A., Willims, J., Brimhall , I. & Hoyes , R.R, (2006). Effects of biodiesel blends on vehicle emissions. Fiscal year 2006 annual operating plan milestone 10.4. national renewable energy laboratory.
Rakopoloulos, D.C., Kakaras, E.C., & Giakoumis, E.G., (2008). Effects of ethanol-diesel fuel blends on the performance and exhaust emissions of heavy duty DI diesel engine. Energy Conversion and
Management, Elsevier, Greece.
Salles, E., Zambotti, A., Gouvea, A., & Agenor, A., (2008). An experimental study of diesel-ehanol
combustion controlled electronically, Robert Bosch Research Manuscript.
Salokhe, V.M., Majumder, B. & Islam, M.S., (1995). Vibration characteristics of power tiller. Journal of Terramechanics, 32, 181-196.
Sam, B., kathirvel, k., (2006). Vibration characterisztics of walking and riding type power tillers. Biosystems Engineering, 95(4), 517-528.
Shabani, Z., Rafiee, S., Ghobadian, B. & Ahmadi, H., (1391). Optimize engine performance Tractors with a mixture of biofuels, diesel, and ethanol by response surface methodology, Journal of Engine Research, 99. (In Farsi)
Subbaiah, G., Raja-Gopal, K., Hussain, S.A., Durga Prasad, B. & Tirupathi Reddy, K., (2010). Rice bran oil biodiesel as an additive in diesel- ethanol blends for diesel engines. International journal of research and reviews in Applied sciences.3(3), 334-342.
Taghi zadeh-ali saraei, A., (1390). Parametric search of Tractor vibration signal MF399 Using diesel fuel and bio-diesel. Ph. D. dissertation, Tarbiat Modares University. (In Farsi)
Taghi zadeh-ali saraei, A., Ghobadian, B., Tavakoli – hashjin, T. & S. S., Mohtasebie, (2012). Vibration analysis of a diesel engine using biodiesel and pet diesel fuel blends. Fuel, 102, 414-422.
Zoldy, M., (2011). Ethanol-biodiesel-diesel blends as a diesel extender option on compression ignition engines. Transport journal, 26, 303-309
Volume 47, Issue 2 - Serial Number 2
Summer 2016
Pages 329-335

  • Receive Date 31 October 2015
  • Revise Date 26 December 2015
  • Accept Date 31 January 2016